Go back to home

gearbox

Author
Post
Essentials Only Full Version
maccardo94
MR2 Enthusiast
  • Total Posts : 95
  • Scores: 1
  • Reward points: 2192
  • Joined: 2016/04/17 00:04:54
  • Status: offline
2016/05/07 07:28:21 (permalink)
0

gearbox

I have a 92 na sw20 .the gear shifter feels quite loose between gears and especially when in neutral.is this a shifter problem or gearbox problem 😵

Thanks
#1


3 Replies Related Threads
    5SGTE
    MR2 Deity
    • Total Posts : 1909
    • Scores: 163
    • Reward points: 4724
    • Joined: 2011/04/07 19:51:15
    • Location: qld Australia
    • Status: offline
    Re: gearbox 2016/05/07 07:53:47 (permalink)
    0
    I'd check shifter linkages, start at gearbox end and check the bushes at the end of the cables. I only have e153 experience but would think yours has the small square bush that's prone to wear. This link might help,

    http://www.alltrac.net/ph...p;t=42245&start=15
    #2
    Reddtarga
    MR2 Deity
    • Total Posts : 2175
    • Scores: 249
    • Reward points: 5547
    • Joined: 2011/04/07 19:51:15
    • Location: Vic Australia
    • Status: offline
    Re: gearbox 2016/05/07 09:45:43 (permalink)
    0
    That square block:
    The S54 transmission has a steel square bush that can often be rotated 90 degrees (if it hasn't been done already) but it is only very cheap from the dealer anyway.
    Job can be done easily from the top of the engine bay.
    To undo the 2 bellcrank holding bolts, remove the airbox assy, and loosen the starter motor holding bolts and tilt it (no need to fully remove it) just enough to loosen the partially hidden stud underneath (middle right in the pic). You can then access the square block (middle left in the pic)
    Grease it when you put it back.

    post edited by Reddtarga - 2016/05/07 09:50:50

    1990 ADM NA
     
     
     
     
     
     
    #3

    Reddtarga
    MR2 Deity
    • Total Posts : 2175
    • Scores: 249
    • Reward points: 5547
    • Joined: 2011/04/07 19:51:15
    • Location: Vic Australia
    • Status: offline
    Re: gearbox 2016/05/07 09:55:08 (permalink)
    0
    I just found this pic of a worn S54 trans block:

     
     

    1990 ADM NA
     
     
     
     
     
     
    #4
    Jump to:
    © 2025 APG vNext Trial Version 5.5